RPM Cabinet Door Gasket Replacement

Last Updated: 04/24/2025 1:46 AM

The following table lists all the components that make up the document.

Title Type Status Last Updated
Rapiscan VM-250 Vehicle Monitor
Device
Published
10/14/2024 9:50 AM
Rapiscan CM-267 Conveyor Monitor
Device
Published
06/27/2024 1:02 PM
Rapiscan TM-850 Rail Monitor
Device
Published
09/18/2024 10:28 AM
Rapiscan PM-700 Pedestrian Monitor
Device
Published
06/20/2024 11:38 AM
1402 - 7927 - Establish Initial Conditions; Remark:
Procedure Step
Published
09/30/2022 1:47 PM
7927 - Establish Initial Conditions
Instruction
Published
07/12/2023 12:23 AM
10199 - 10198 - Assess if weather conditions are suitable to complete the full procedure ...; Remark:10197
Procedure Step
Published
10/24/2023 8:01 PM
10198 - Assess if weather conditions are suitable to complete the full procedure ...
Instruction
Published
10/24/2023 8:00 PM
10197 - If the temperature is below 10°C (50°F) or the door is damp due to rain or ...
Remark
Published
10/24/2023 8:01 PM
7268 - 7231 - Close lane; Remark:7233
Procedure Step
Published
04/27/2023 7:01 PM
9053 - Warning : Traffic should temporarily be rerouted or halted during conduction of this pr...
Annotation
Published
09/27/2023 9:09 AM
7231 - Close lane
Instruction
Published
04/18/2023 1:00 PM
7233 - Use orange safety (traffic control) cones to setup barriers. Practice establi...
Remark
Published
04/24/2023 12:18 PM
10196 - 10192 - Remove Old Gasket; Remark:
Procedure Step
Published
10/24/2023 8:05 PM
10192 - Remove Old Gasket
Instruction
Published
10/24/2023 8:02 PM
10188 - 10187 - Use putty knife to scrape gasket from door; Remark:10186
Procedure Step
Published
10/24/2023 8:06 PM
10193 - Note : Replacement gasket must be obtained prior to starting. The peel and stick gas...
Annotation
Published
10/24/2023 8:03 PM
10194 - Note : May be ordered from Rapiscan on a “per foot” basis, Part No. 6987G.
Annotation
Published
10/24/2023 8:03 PM
10195 - Note : For ordering, the total length required is shown in Total Gasket Length table...
Annotation
Published
10/24/2023 8:05 PM
10187 - Use putty knife to scrape gasket from door
Instruction
Published
10/24/2023 8:06 PM
10186 - Use care to not scrape the paint.
Remark
Published
10/24/2023 8:06 PM
10189 - 10185 - Discard loose material; Remark:
Procedure Step
Published
10/24/2023 8:07 PM
10185 - Discard loose material
Instruction
Published
10/24/2023 8:07 PM
10190 - 10184 - Apply acetone directly onto residue; Remark:10182
Procedure Step
Published
10/24/2023 8:08 PM
10184 - Apply acetone directly onto residue
Instruction
Published
10/24/2023 8:08 PM
10182 - Either spray or squirt Acetone onto residue and allow soaking for a few minut...
Remark
Published
10/24/2023 8:08 PM
10183 - Use care to not scrape the paint. A razor blade and acetone may be necessary ...
Remark
Published
10/24/2023 8:08 PM
10191 - 10181 - Remove any remaining adhesive; Remark:10180
Procedure Step
Published
10/24/2023 8:09 PM
10181 - Remove any remaining adhesive
Instruction
Published
10/24/2023 8:09 PM
10180 - Use additional acetone and paper towels as needed.
Remark
Published
10/24/2023 8:09 PM
10179 - 10178 - Prep Area for Install of New Gasket; Remark:
Procedure Step
Published
10/24/2023 8:11 PM
10178 - Prep Area for Install of New Gasket
Instruction
Published
10/24/2023 8:11 PM
10175 - 10174 - Clean affected surface with rubbing alcohol and paper towels; Remark:10173
Procedure Step
Published
10/24/2023 8:12 PM
10174 - Clean affected surface with rubbing alcohol and paper towels
Instruction
Published
10/24/2023 8:12 PM
10173 - Remaining adhesive will become slightly sticky.
Remark
Published
10/24/2023 8:12 PM
10176 - 10172 - Wait until conditions are optimal; Remark:10169
Procedure Step
Published
10/24/2023 8:15 PM
10172 - Wait until conditions are optimal
Instruction
Published
10/24/2023 8:13 PM
10169 - To help promote a strong bond, the surface area needs to be free of the origi...
Remark
Published
10/24/2023 8:13 PM
10170 - If the temperature is below 10°C (50°F) or the door is damp due to rain or ...
Remark
Published
10/24/2023 8:14 PM
10171 - If removing the doors, be sure to protect the electronics and detectors from ...
Remark
Published
10/24/2023 8:14 PM
10177 - 10167 - Measure and cut appropriate lengths of gasket material required; Remark:10164
Procedure Step
Published
10/24/2023 8:18 PM
10168 - Caution : Incomplete seals may cause environmental damage to the cabinet contents. Gask...
Annotation
Published
10/24/2023 8:18 PM
10167 - Measure and cut appropriate lengths of gasket material required
Instruction
Published
10/24/2023 8:15 PM
10164 - Use scissors and measuring tape.
Remark
Published
10/24/2023 8:16 PM
10165 - Use Gasket Segment Lengths table for appropriate gasket lengths.
Remark
Published
10/24/2023 8:16 PM
10166 - Suggested technique is to add 3-5 cm to the listed length for the initial cut...
Remark
Published
10/24/2023 8:17 PM
10202 - Gasket Segment Lengths
Remark
Published
10/24/2023 8:31 PM
10203 - 10200 - Mark gasket location on door using attached drawing; Remark:
Procedure Step
Published
10/24/2023 8:34 PM
10201 - Standard : The gasket spacing to the door edge on the top, lock side, and bottom is appr...
Annotation
Published
10/24/2023 8:34 PM
10200 - Mark gasket location on door using attached drawing
Instruction
Published
10/24/2023 8:33 PM
10230 - 10229 - Preheat gasket and/or contact area; Remark:10228
Procedure Step
Published
10/24/2023 9:28 PM
10229 - Preheat gasket and/or contact area
Instruction
Published
10/24/2023 9:28 PM
10228 - Use a hair dryer or similar device until gasket is warm to your touch. This w...
Remark
Published
10/24/2023 9:28 PM
10227 - 10226 - Install New Gasket; Remark:10225
Procedure Step
Published
10/24/2023 9:34 PM
10226 - Install New Gasket
Instruction
Published
10/24/2023 9:29 PM
10225 - gasket application order
Remark
Published
10/24/2023 9:34 PM
10221 - 10220 - Peel protective paper backing from top gasket and attach adhesive side of gas...; Remark:10219
Procedure Step
Published
10/24/2023 9:36 PM
10314 - Caution : Do not stretch or pull the gaskets when placing them on the door as this can ...
Annotation
Published
11/17/2023 8:56 AM
10315 - Note : Attaching the gaskets to the door in the correct sequence is important to kee...
Annotation
Published
11/17/2023 8:57 AM
10220 - Peel protective paper backing from top gasket and attach adhesive side of gas...
Instruction
Published
10/24/2023 9:36 PM
10219 - (This is the first application.) Use care when removing/peeling backing paper...
Remark
Published
10/24/2023 9:36 PM
10222 - 10218 - Peel protective paper backing from side gasket and attach adhesive side of ga...; Remark:10217
Procedure Step
Published
10/24/2023 9:37 PM
10218 - Peel protective paper backing from side gasket and attach adhesive side of ga...
Instruction
Published
10/24/2023 9:36 PM
10217 - (This is the second application.)
Remark
Published
10/24/2023 9:37 PM
10223 - 10216 - Peel protective paper backing from side gasket and attach adhesive side of ga...; Remark:10215
Procedure Step
Published
10/24/2023 9:38 PM
10216 - Peel protective paper backing from side gasket and attach adhesive side of ga...
Instruction
Published
10/24/2023 9:38 PM
10215 - (This is the third application.)
Remark
Published
10/24/2023 9:38 PM
10224 - 10214 - Peel protective paper backing from bottom gasket and attach adhesive side of ...; Remark:10213
Procedure Step
Published
10/24/2023 9:40 PM
10214 - Peel protective paper backing from bottom gasket and attach adhesive side of ...
Instruction
Published
10/24/2023 9:39 PM
10213 - (This is the fourth application.)
Remark
Published
10/24/2023 9:39 PM
7279 - 7249 - Return equipment to normal operating condition; Remark:
Procedure Step
Published
04/27/2023 4:13 PM
7249 - Return equipment to normal operating condition
Instruction
Published
04/08/2025 3:22 PM
10210 - 10209 - Close cabinet door; Remark:
Procedure Step
Published
10/24/2023 9:42 PM
10209 - Close cabinet door
Instruction
Published
10/24/2023 9:42 PM
10211 - 10207 - Keep door closed for at least 24 hours; Remark:10206
Procedure Step
Published
10/24/2023 9:44 PM
10208 - Note : Cure times vary depending on temperature and humidity.
Annotation
Published
10/24/2023 9:44 PM
10207 - Keep door closed for at least 24 hours
Instruction
Published
10/24/2023 9:43 PM
10206 - The constant pressure of the door will help create a strong bond during the 2...
Remark
Published
10/24/2023 9:44 PM
10212 - 10205 - Check gasket adhesion at end of 24 hours; Remark:10204
Procedure Step
Published
10/24/2023 9:46 PM
10205 - Check gasket adhesion at end of 24 hours
Instruction
Published
10/24/2023 9:45 PM
10204 - Check temperature or cleanliness of surface if gasket does not adhere properl...
Remark
Published
10/24/2023 9:46 PM
8260 - 8250 - Reopen Lane; Remark:8249
Procedure Step
Published
09/07/2023 3:09 PM
8250 - Reopen Lane
Instruction
Published
09/07/2023 3:09 PM
8249 - Remove orange safety (traffic control) cones
Remark
Published
09/07/2023 3:09 PM
7842 - 7820 - Inform system operators upon completion of maintenance action; Remark:
Procedure Step
Published
07/07/2023 11:15 PM
7820 - Inform system operators upon completion of maintenance action
Instruction
Published
07/07/2023 10:02 PM
322 - 321 - Document maintenance actions; Remark:
Procedure Step
Published
06/17/2021 9:49 AM
321 - Document maintenance actions
Instruction
Published
04/21/2025 11:19 AM
2869 - 2585 - Document maintenance performed; Remark:2866
Procedure Step
Published
06/18/2021 5:58 PM
2585 - Document maintenance performed
Instruction
Published
07/09/2021 12:15 PM
2866 - Record observations, times, and results for the maintenance report.
Remark
Published
04/21/2025 11:39 AM
4706 - 4705 - Submit report; Remark:4864
Procedure Step
Published
06/29/2022 9:50 AM
4705 - Submit report
Instruction
Published
06/29/2022 9:50 AM
4864 - As specified by management or contractual obligations.
Remark
Published
07/28/2022 1:36 PM
Corrective Maintenance Procedure
Document Type
Published
03/02/2020 3:32 PM
hours
Duration
Published
05/26/2022 11:45 AM
Upon damage or no longer sealing properly
Frequency
Published
10/23/2023 3:03 PM
Warning
Annotation Type
Published
03/02/2020 3:25 PM
Note
Annotation Type
Published
03/02/2020 3:25 PM
Caution
Annotation Type
Published
03/02/2020 3:24 PM
Standard
Annotation Type
Published
03/02/2020 3:25 PM
Technician 1
Skill Level
Published
05/14/2020 2:56 PM
Narrow putty knife or paint scraper
Tools
Published
10/23/2023 4:18 PM
Razor blade scraper
Tools
Published
10/23/2023 4:18 PM
Measuring Tape
Tools
Published
10/03/2023 10:11 AM
Scissors
Tools
Published
05/19/2020 1:54 PM
Permanent marker
Tools
Published
10/23/2023 10:07 AM
Keys to access RPM
Replacement Parts
Published
04/27/2023 6:56 PM
Ladder: 2 meters, 6 feet tall; non-conducting
Replacement Parts
Published
09/01/2023 9:34 PM
Orange traffic cones
Replacement Parts
Published
04/27/2023 6:56 PM
safety glasses
Replacement Parts
Published
07/02/2023 4:48 PM
Gloves
Replacement Parts
Published
05/10/2023 3:28 PM
Gasket segment lengths_0.png
Image
Published
10/24/2023 9:23 PM
gasket application order
Image
Published
10/24/2023 9:33 PM

PRM-470 Charging Port Replacement

Last Updated: 04/24/2025 1:35 AM

The following table lists all the components that make up the document.

Title Type Status Last Updated
Rapiscan PRM-470 CG
Device
Published
10/28/2024 3:40 PM
Rapiscan PRM-470 CGN
Device
Published
10/28/2024 3:33 PM
247 - 257 - Prepare instrument; Remark:
Procedure Step
Published
04/11/2025 9:08 PM
257 - Prepare instrument
Instruction
Published
04/11/2025 9:07 PM
607 - 205 - Disconnect charger; Remark:
Procedure Step
Published
07/23/2021 2:42 PM
205 - Disconnect charger
Instruction
Published
07/23/2021 2:42 PM
397 - 313 - Power off instrument; Remark:398
Procedure Step
Published
06/11/2021 9:31 AM
313 - Power off instrument
Instruction
Published
07/23/2021 2:41 PM
398 - Press and hold the POWER button until instrument powers off....
Remark
Published
06/18/2021 6:02 PM
275 - 65 - Loosen four (4) cover screws; Remark:264
Procedure Step
Published
07/26/2021 12:42 PM
65 - Loosen four (4) cover screws
Instruction
Published
07/22/2021 12:38 PM
264 - Use a medium Phillips (PH2) screwdriver. Screws do not need to be completely ...
Remark
Published
07/20/2021 3:59 PM
263 - 262 - Remove instrument cover; Remark:413
Procedure Step
Published
08/11/2021 1:41 PM
2771 - Note : There are high-voltage detector circuit boards inside the instrument; however...
Annotation
Published
10/04/2022 11:06 AM
262 - Remove instrument cover
Instruction
Published
07/20/2021 3:35 PM
413 - PRM-470 Remove Instrument Cover
Remark
Published
11/01/2024 8:32 PM
276 - 266 - Locate battery connection; Remark:265
Procedure Step
Published
08/11/2021 3:07 PM
3033 - Note : PRM-470 CGN models have an additional board and connectors not shown in remar...
Annotation
Published
10/04/2022 11:07 AM
266 - Locate battery connection
Instruction
Published
07/20/2021 3:36 PM
265 - Battery connection is labeled 1.
Remark
Published
08/07/2021 11:16 AM
271 - 270 - Disconnect battery; Remark:414
Procedure Step
Published
08/11/2021 1:42 PM
1345 - Note : It is good practice to ensure all cables and connectors are labeled prior to ...
Annotation
Published
10/04/2022 11:08 AM
270 - Disconnect battery
Instruction
Published
07/20/2021 3:37 PM
414 - PRM-470_Disconnect_battery
Remark
Published
11/02/2024 1:21 PM
443 - 442 - Disconnect remaining connectors; Remark:
Procedure Step
Published
08/11/2021 1:43 PM
442 - Disconnect remaining connectors
Instruction
Published
07/22/2021 12:39 PM
717 - 716 - Unbundle wiring; Remark:715
Procedure Step
Published
08/12/2021 7:49 AM
716 - Unbundle wiring
Instruction
Published
08/11/2021 11:56 AM
715 - Carefully cut wire ties with scissors, knife or clippers. Remove foam (if pre...
Remark
Published
08/11/2021 11:57 AM
719 - 718 - Replace charging port; Remark:
Procedure Step
Published
08/11/2021 3:07 PM
718 - Replace charging port
Instruction
Published
08/11/2021 11:58 AM
728 - 724 - Detach port from case; Remark:720
Procedure Step
Published
08/11/2021 3:08 PM
724 - Detach port from case
Instruction
Published
08/11/2021 11:59 AM
720 - Using pliers or slotted screwdriver, carefully push locking tabs on side of p...
Remark
Published
08/11/2021 12:00 PM
729 - 725 - Remove faulty charging port and cable; Remark:721
Procedure Step
Published
08/11/2021 3:08 PM
725 - Remove faulty charging port and cable
Instruction
Published
08/11/2021 12:01 PM
721 - PRM-470 - the old charging port is pulled out of the charger body
Remark
Published
11/02/2024 5:11 PM
730 - 726 - Insert new charging port; Remark:722
Procedure Step
Published
08/11/2021 3:10 PM
726 - Insert new charging port
Instruction
Published
08/11/2021 12:02 PM
722 - Insert new charging port wiring through opening in case, white connector firs...
Remark
Published
08/11/2021 12:03 PM
731 - 727 - Secure new charging port; Remark:723
Procedure Step
Published
08/11/2021 3:10 PM
727 - Secure new charging port
Instruction
Published
08/11/2021 12:04 PM
723 - Align port with opening and snap into place. Place the key notch toward the b...
Remark
Published
08/11/2021 12:06 PM
303 - 302 - Reassemble instrument; Remark:
Procedure Step
Published
10/07/2022 1:49 PM
302 - Reassemble instrument
Instruction
Published
06/16/2021 11:28 PM
500 - 498 - Reconnect all connectors except battery; Remark:499
Procedure Step
Published
08/11/2021 2:02 PM
498 - Reconnect all connectors except battery
Instruction
Published
07/22/2021 1:02 PM
499 - Do not connect location 1.
Remark
Published
07/22/2021 1:17 PM
306 - 305 - Reconnect battery; Remark:416
Procedure Step
Published
08/11/2021 3:11 PM
305 - Reconnect battery
Instruction
Published
07/29/2021 3:48 PM
416 - PRM-470 Battery Replacement - Reconnect battery
Remark
Published
11/02/2024 2:02 PM
734 - 733 - Secure wiring; Remark:732
Procedure Step
Published
08/12/2021 7:50 AM
733 - Secure wiring
Instruction
Published
08/11/2021 12:07 PM
732 - Bind wiring together with new wire ties. Cut excess wire tie material. Reinse...
Remark
Published
08/11/2021 12:08 PM
308 - 307 - Replace front cover; Remark:
Procedure Step
Published
08/11/2021 2:03 PM
304 - Caution : Ensure all wiring is inside the instrument while replacing cover.
Annotation
Published
10/04/2022 11:10 AM
307 - Replace front cover
Instruction
Published
07/20/2021 3:57 PM
310 - 309 - Tighten four (4) cover screws; Remark:417
Procedure Step
Published
08/11/2021 2:04 PM
569 - Caution : Do not overtighten screws.
Annotation
Published
06/16/2021 2:31 PM
309 - Tighten four (4) cover screws
Instruction
Published
07/22/2021 1:02 PM
417 - Use a medium Phillips (PH2) screwdriver.
Remark
Published
07/22/2021 1:18 PM
312 - 311 - Verify instrument charges successfully; Remark:
Procedure Step
Published
07/20/2021 10:53 AM
311 - Verify instrument charges successfully
Instruction
Published
07/20/2021 10:44 AM
316 - 315 - Connect charger; Remark:289
Procedure Step
Published
07/29/2021 3:07 PM
315 - Connect charger
Instruction
Published
07/20/2021 10:45 AM
289 - Plug charger into instrument and AC power outlet
Remark
Published
07/20/2021 10:48 AM
739 - 737 - Observe smart charger status; Remark:735
Procedure Step
Published
08/11/2021 3:12 PM
737 - Observe smart charger status
Instruction
Published
08/11/2021 12:10 PM
735 - The charger has a blinking yellow light when it is charging
Remark
Published
08/11/2021 12:11 PM
322 - 321 - Document maintenance actions; Remark:
Procedure Step
Published
06/17/2021 9:49 AM
321 - Document maintenance actions
Instruction
Published
04/21/2025 11:19 AM
2869 - 2585 - Document maintenance performed; Remark:2866
Procedure Step
Published
06/18/2021 5:58 PM
2585 - Document maintenance performed
Instruction
Published
07/09/2021 12:15 PM
2866 - Record observations, times, and results for the maintenance report.
Remark
Published
04/21/2025 11:39 AM
4706 - 4705 - Submit report; Remark:4864
Procedure Step
Published
06/29/2022 9:50 AM
4705 - Submit report
Instruction
Published
06/29/2022 9:50 AM
4864 - As specified by management or contractual obligations.
Remark
Published
07/28/2022 1:36 PM
Corrective Maintenance Procedure
Document Type
Published
03/02/2020 3:32 PM
20 minutes
Duration
Published
05/18/2020 5:44 PM
As Needed
Frequency
Published
04/01/2020 11:36 AM
Note
Annotation Type
Published
03/02/2020 3:25 PM
Caution
Annotation Type
Published
03/02/2020 3:24 PM
Technician 2
Skill Level
Published
04/09/2020 1:17 AM
Medium Phillips (PH2) screwdriver
Tools
Published
04/24/2020 4:40 PM
Needle nose pliers
Tools
Published
05/06/2020 4:10 PM
Scissors
Tools
Published
05/19/2020 1:54 PM
Utility knife
Tools
Published
05/19/2020 1:54 PM
PRM-470_Partial_Power_Button_Red_Highlight.png
Image
Published
06/18/2021 6:28 PM
PRM470_Remove_Screws_Top_Case
Image
Published
05/08/2020 6:05 PM
PRM-470_di_CGN_open_00536
Image
Published
02/19/2023 11:26 AM
PRM470_Battery_connection_is_labeled_1
Image
Published
02/19/2023 10:40 AM
PRM-470_Disconnect_battery
Image
Published
05/09/2020 8:40 PM
PRM-470_Unbundle_wires
Image
Published
05/19/2020 3:00 PM
PRM-470 Detach port from case
Image
Published
05/19/2020 3:19 PM
PRM-470 - Remove old charging port
Image
Published
05/19/2020 3:22 PM
PRM-470 - Insert new charging port
Image
Published
05/19/2020 3:25 PM
PRM-470 - Secure new charging port
Image
Published
05/19/2020 3:30 PM
PRM-470_Reconnect_battery
Image
Published
05/10/2020 8:16 PM
PRM-470 - Bind wiring together
Image
Published
05/19/2020 3:52 PM
PRM-470_Tighten_4_cover_screws
Image
Published
05/10/2020 8:22 PM
PRM-470 Port for Charging Cord Red Arrow
Image
Published
05/09/2020 1:49 PM
PRM-470 Charger_New Wall Plug Red Arrow
Image
Published
05/09/2020 1:47 PM
PRM-470 - Smart Charger Light
Image
Published
05/19/2020 4:14 PM