| Rapiscan VM-250 Vehicle Monitor |
Device
|
Published
|
10/14/2024 9:50 AM
|
| Rapiscan TM-850 Rail Monitor |
Device
|
Published
|
09/18/2024 10:28 AM
|
| 8468 - 1401 - Establish Initial Conditions; Remark: |
Procedure Step
|
Published
|
09/16/2023 4:47 PM
|
| 1401 - Establish Initial Conditions |
Instruction
|
Published
|
09/30/2022 3:14 PM
|
| 8490 - 7592 - Inform system operators; Remark: |
Procedure Step
|
Published
|
09/16/2023 8:49 PM
|
| 7592 - Inform system operators |
Instruction
|
Published
|
06/29/2023 3:20 PM
|
| 8221 - 7676 - Brief system operators on expected work, duration, anticipated alarms, and fa...; Remark: |
Procedure Step
|
Published
|
09/01/2023 9:26 PM
|
| 7676 - Brief system operators on expected work, duration, anticipated alarms, and fa... |
Instruction
|
Published
|
07/01/2023 11:39 PM
|
| 10267 - 7967 - Close lane and set up barriers or establish a safety watch; Remark:7571 |
Procedure Step
|
Published
|
11/10/2023 1:41 PM
|
| 7678 - Warning : Traffic should temporarily be rerouted or halted during conduction of this pr... |
Annotation
|
Published
|
07/03/2023 10:23 AM
|
| 7967 - Close lane and set up barriers or establish a safety watch |
Instruction
|
Published
|
07/12/2023 12:41 AM
|
| 7571 - Use orange safety cones or equivalent based on site-specific safety practices... |
Remark
|
Published
|
06/20/2023 4:42 PM
|
| 10268 - 9235 - Open Control pillar RPM door; Remark: |
Procedure Step
|
Published
|
11/10/2023 1:42 PM
|
| 9235 - Open Control pillar RPM door |
Instruction
|
Published
|
10/03/2023 12:03 PM
|
| 7270 - 7235 - Power off RPM; Remark:7236 |
Procedure Step
|
Published
|
09/01/2023 7:57 PM
|
| 7235 - Power off RPM |
Instruction
|
Published
|
04/24/2023 12:30 PM
|
| 7236 - Move LD-260 switch to OFF position. The PWR ON |
Remark
|
Published
|
04/27/2023 4:25 PM
|
| 8748 - 8747 - Disconnect ELK Siren Wiring; Remark: |
Procedure Step
|
Published
|
09/24/2023 10:25 PM
|
| 8747 - Disconnect ELK Siren Wiring |
Instruction
|
Published
|
09/24/2023 10:24 PM
|
| 8803 - 8673 - Locate terminal block TB4; Remark:8674 |
Procedure Step
|
Published
|
09/25/2023 9:59 AM
|
| 7792 - Note : It is good engineering practice to ensure all cables and connectors are label... |
Annotation
|
Published
|
07/07/2023 2:17 PM
|
| 8673 - Locate terminal block TB4 |
Instruction
|
Published
|
09/24/2023 10:02 AM
|
| 8674 - For vehicle monitors: Open the upper RPM door |
Remark
|
Published
|
09/24/2023 9:58 AM
|
| 8751 - 8749 - Disconnect wires from terminal block TB4; Remark:8750 |
Procedure Step
|
Published
|
09/24/2023 10:31 PM
|
| 8749 - Disconnect wires from terminal block TB4 |
Instruction
|
Published
|
09/24/2023 10:28 PM
|
| 8750 - Using a flathead screwdriver, disconnect wires: Red wire - ... |
Remark
|
Published
|
09/24/2023 10:30 PM
|
| 8753 - 8678 - Release wiring harness from fasteners; Remark:8752 |
Procedure Step
|
Published
|
04/13/2025 6:16 PM
|
| 8678 - Release wiring harness from fasteners |
Instruction
|
Published
|
04/13/2025 6:10 PM
|
| 8752 - Using cutter pliers, remove associated fasteners from TB4 Pin 8 |
Remark
|
Published
|
09/24/2023 10:45 PM
|
| 8755 - 8754 - Uninstall Faulty ELK Siren and Housing; Remark: |
Procedure Step
|
Published
|
09/24/2023 10:47 PM
|
| 8754 - Uninstall Faulty ELK Siren and Housing |
Instruction
|
Published
|
09/24/2023 10:46 PM
|
| 8758 - 8756 - Remove screw located on bottom of ELK siren housing; Remark:8757 |
Procedure Step
|
Published
|
09/24/2023 10:50 PM
|
| 8756 - Remove screw located on bottom of ELK siren housing |
Instruction
|
Published
|
09/24/2023 10:47 PM
|
| 8757 - Turn screw counterclockwise using an 11 mm wrench. |
Remark
|
Published
|
09/24/2023 10:49 PM
|
| 8761 - 8759 - Remove outer casing of ELK siren; Remark:8760 |
Procedure Step
|
Published
|
09/24/2023 10:52 PM
|
| 8759 - Remove outer casing of ELK siren |
Instruction
|
Published
|
09/24/2023 10:50 PM
|
| 8760 - Lower outer casing approximately ½” (12 mm), pull casing away from door ap... |
Remark
|
Published
|
09/24/2023 10:51 PM
|
| 8764 - 8762 - Remove ELK siren; Remark:8763 |
Procedure Step
|
Published
|
09/24/2023 10:55 PM
|
| 8762 - Remove ELK siren |
Instruction
|
Published
|
09/24/2023 10:52 PM
|
| 8763 - Pull the siren away from the housing assembly. Ensure when removing to pull s... |
Remark
|
Published
|
09/24/2023 10:54 PM
|
| 8766 - 8765 - Carefully pull ELK siren thorugh door without losing grommet; Remark: |
Procedure Step
|
Published
|
09/24/2023 10:57 PM
|
| 8765 - Carefully pull ELK siren thorugh door without losing grommet |
Instruction
|
Published
|
09/24/2023 10:57 PM
|
| 8770 - 8767 - Remove screws and nuts; Remark:8769 |
Procedure Step
|
Published
|
09/24/2023 11:02 PM
|
| 8768 - Caution : While removing the hardware, the enclosure mount will come loose. Take care n... |
Annotation
|
Published
|
09/24/2023 10:58 PM
|
| 8767 - Remove screws and nuts |
Instruction
|
Published
|
09/24/2023 10:58 PM
|
| 8769 - Using an adjustable wrench, hold nuts on the inside of the door while using a... |
Remark
|
Published
|
09/24/2023 11:01 PM
|
| 8771 - 8693 - Remove residue off RPM door; Remark: |
Procedure Step
|
Published
|
09/24/2023 11:04 PM
|
| 8693 - Remove residue off RPM door |
Instruction
|
Published
|
09/24/2023 1:22 PM
|
| 3397 - 3395 - Label faulty component; Remark:3396 |
Procedure Step
|
Published
|
07/21/2024 6:59 AM
|
| 3395 - Label faulty component |
Instruction
|
Published
|
08/07/2021 11:07 AM
|
| 3396 - Use tag or tape. Include date of removal, description of failure symptoms, co... |
Remark
|
Published
|
08/09/2021 11:35 AM
|
| 8773 - 8772 - Install New ELK Siren Housing and Siren; Remark: |
Procedure Step
|
Published
|
09/24/2023 11:07 PM
|
| 8772 - Install New ELK Siren Housing and Siren |
Instruction
|
Published
|
09/24/2023 11:06 PM
|
| 8776 - 8774 - Attach new ELK siren mount; Remark: |
Procedure Step
|
Published
|
09/24/2023 11:10 PM
|
| 8774 - Attach new ELK siren mount |
Instruction
|
Published
|
09/24/2023 11:08 PM
|
| 8777 - 8775 - Apply a light amount of silicone around nuts on back side of door; Remark: |
Procedure Step
|
Published
|
09/24/2023 11:11 PM
|
| 8701 - Warning : Use protective gloves when handling silicone. |
Annotation
|
Published
|
09/24/2023 1:50 PM
|
| 8775 - Apply a light amount of silicone around nuts on back side of door |
Instruction
|
Published
|
09/24/2023 11:09 PM
|
| 8780 - 8778 - Feed ELK siren wires through grommet located in door; Remark:8779 |
Procedure Step
|
Published
|
09/24/2023 11:19 PM
|
| 8778 - Feed ELK siren wires through grommet located in door |
Instruction
|
Published
|
09/24/2023 11:17 PM
|
| 8779 - ELK Siren Wires |
Remark
|
Published
|
09/24/2023 11:18 PM
|
| 8783 - 8781 - Slide new ELK siren onto ELK siren housing tab; Remark:8782 |
Procedure Step
|
Published
|
09/24/2023 11:22 PM
|
| 8781 - Slide new ELK siren onto ELK siren housing tab |
Instruction
|
Published
|
09/24/2023 11:19 PM
|
| 8782 - ELK Siren Housing Tab |
Remark
|
Published
|
09/24/2023 11:21 PM
|
| 8785 - 8784 - Apply a light amount of silicone around wires and grommet on back side of doo...; Remark: |
Procedure Step
|
Published
|
09/24/2023 11:23 PM
|
| 8784 - Apply a light amount of silicone around wires and grommet on back side of doo... |
Instruction
|
Published
|
09/24/2023 11:22 PM
|
| 8788 - 8786 - Reinstall ELK siren housing outer case; Remark:8787 |
Procedure Step
|
Published
|
09/24/2023 11:26 PM
|
| 8786 - Reinstall ELK siren housing outer case |
Instruction
|
Published
|
09/24/2023 11:24 PM
|
| 8787 - The tabs on the outer casing must fit in the U-shaped slot on the housing ass... |
Remark
|
Published
|
09/24/2023 11:25 PM
|
| 8791 - 8789 - Install screw located on bottom of ELK siren housing.; Remark:8790 |
Procedure Step
|
Published
|
09/24/2023 11:28 PM
|
| 8789 - Install screw located on bottom of ELK siren housing. |
Instruction
|
Published
|
09/24/2023 11:27 PM
|
| 8790 - ELK Siren Bottom Screw |
Remark
|
Published
|
09/24/2023 11:27 PM
|
| 8794 - 8793 - Reconnect ELK Siren Wiring; Remark: |
Procedure Step
|
Published
|
09/24/2023 11:31 PM
|
| 8793 - Reconnect ELK Siren Wiring |
Instruction
|
Published
|
09/24/2023 11:31 PM
|
| 8792 - 8673 - Locate terminal block TB4; Remark:8674 |
Procedure Step
|
Published
|
09/24/2023 11:30 PM
|
| 8797 - 8795 - Connect wires to terminal block TB4; Remark:8796 |
Procedure Step
|
Published
|
09/24/2023 11:34 PM
|
| 8795 - Connect wires to terminal block TB4 |
Instruction
|
Published
|
09/24/2023 11:31 PM
|
| 8796 - Using a flathead screwdriver, connect wires: Red wire - Pin... |
Remark
|
Published
|
09/24/2023 11:33 PM
|
| 8799 - 8714 - Add wire fasteners where removed; Remark:8798 |
Procedure Step
|
Published
|
09/24/2023 11:37 PM
|
| 8714 - Add wire fasteners where removed |
Instruction
|
Published
|
09/24/2023 2:16 PM
|
| 8798 - Adding ELK Siren Wiring Fasteners |
Remark
|
Published
|
09/24/2023 11:37 PM
|
| 7279 - 7249 - Return equipment to normal operating condition; Remark: |
Procedure Step
|
Published
|
04/27/2023 4:13 PM
|
| 7249 - Return equipment to normal operating condition |
Instruction
|
Published
|
04/08/2025 3:22 PM
|
| 8503 - 7250 - Power on RPM; Remark:7251 |
Procedure Step
|
Published
|
09/16/2023 9:00 PM
|
| 7250 - Power on RPM |
Instruction
|
Published
|
05/01/2023 8:31 AM
|
| 7251 - Move LD-260 switch to ON position. The LED PWR ON |
Remark
|
Published
|
05/10/2023 3:14 PM
|
| 8801 - 8800 - Listen for the siren to activate; Remark: |
Procedure Step
|
Published
|
04/13/2025 6:15 PM
|
| 8800 - Listen for the siren to activate |
Instruction
|
Published
|
04/13/2025 6:09 PM
|
| 8670 - 319 - Perform operational test; Remark:8669 |
Procedure Step
|
Published
|
04/08/2025 2:20 PM
|
| 319 - Perform operational test |
Instruction
|
Published
|
06/10/2021 8:31 PM
|
| 8669 - DET-RPM-RAP-RM03, RPM Operational Testing |
Remark
|
Published
|
09/20/2023 4:18 PM
|
| 8506 - 7254 - Confirm network connection; Remark:7255 |
Procedure Step
|
Published
|
09/24/2023 3:34 PM
|
| 7254 - Confirm network connection |
Instruction
|
Published
|
04/27/2023 2:22 PM
|
| 7255 - Contact operators to confirm communications have been reestablished between RPM ... |
Remark
|
Published
|
05/10/2023 3:15 PM
|
| 8507 - 7256 - Close and lock all RPM doors; Remark: |
Procedure Step
|
Published
|
09/24/2023 3:35 PM
|
| 7256 - Close and lock all RPM doors |
Instruction
|
Published
|
04/27/2023 2:21 PM
|
| 7842 - 7820 - Inform system operators upon completion of maintenance action; Remark: |
Procedure Step
|
Published
|
07/07/2023 11:15 PM
|
| 7820 - Inform system operators upon completion of maintenance action |
Instruction
|
Published
|
07/07/2023 10:02 PM
|
| 322 - 321 - Document maintenance actions; Remark: |
Procedure Step
|
Published
|
06/17/2021 9:49 AM
|
| 321 - Document maintenance actions |
Instruction
|
Published
|
04/21/2025 11:19 AM
|
| 2869 - 2585 - Document maintenance performed; Remark:2866 |
Procedure Step
|
Published
|
06/18/2021 5:58 PM
|
| 2585 - Document maintenance performed |
Instruction
|
Published
|
07/09/2021 12:15 PM
|
| 2866 - Record observations, times, and results for the maintenance report. |
Remark
|
Published
|
04/21/2025 11:39 AM
|
| 4706 - 4705 - Submit report; Remark:4864 |
Procedure Step
|
Published
|
06/29/2022 9:50 AM
|
| 4705 - Submit report |
Instruction
|
Published
|
06/29/2022 9:50 AM
|
| 4864 - As specified by management or contractual obligations. |
Remark
|
Published
|
07/28/2022 1:36 PM
|
| Corrective Maintenance Procedure |
Document Type
|
Published
|
03/02/2020 3:32 PM
|
| Upon failure of ELK siren |
Frequency
|
Published
|
09/25/2023 9:49 AM
|
| Warning |
Annotation Type
|
Published
|
03/02/2020 3:25 PM
|
| Note |
Annotation Type
|
Published
|
03/02/2020 3:25 PM
|
| Caution |
Annotation Type
|
Published
|
03/02/2020 3:24 PM
|
| Technician 1 |
Skill Level
|
Published
|
05/14/2020 2:56 PM
|
| Small slotted (flathead) screwdriver |
Tools
|
Published
|
09/11/2020 11:23 AM
|
| Medium Phillips (PH2) screwdriver |
Tools
|
Published
|
04/24/2020 4:40 PM
|
| Adjustable wrench |
Replacement Parts
|
Published
|
06/02/2023 10:08 PM
|
| Wire cutter pliers |
Tools
|
Published
|
10/27/2022 1:20 PM
|
| Gloves |
Replacement Parts
|
Published
|
05/10/2023 3:28 PM
|
| LD-260 Disconnect Switch Power Off |
படம்
|
Published
|
04/24/2023 12:49 PM
|
| TB4 Siren Wiring |
படம்
|
Published
|
09/24/2023 10:30 PM
|
| ELK Siren Screw |
படம்
|
Published
|
09/24/2023 10:48 PM
|
| Remove ELK Siren |
படம்
|
Published
|
09/24/2023 10:53 PM
|
| ELK Siren Mount |
படம்
|
Published
|
09/24/2023 10:59 PM
|
| ELK Siren Mount Nuts |
படம்
|
Published
|
09/24/2023 11:00 PM
|
| ELK Siren Wires |
படம்
|
Published
|
09/24/2023 11:18 PM
|
| ELK Siren Housing Tab |
படம்
|
Published
|
09/24/2023 11:20 PM
|
| ELK Siren Housing |
படம்
|
Published
|
09/24/2023 11:25 PM
|
| ELK Siren Wiring Fasteners |
படம்
|
Published
|
09/24/2023 11:36 PM
|
| LD-260 Disconnect Switch Power On |
படம்
|
Published
|
05/04/2023 3:37 PM
|
